화학공학소재연구정보센터
Journal of the Korean Industrial and Engineering Chemistry, Vol.10, No.4, 563-567, June, 1999
나권형 역삼투 모듈에 의한 Cephalosporin C의 농축분리에 관한 실험연구
Experimental Study on Separation of Cephalosprotin C by Spiral-Wound Reverse Osmosis Module
초록
용질배제율이 우수한 나권형 FT-30 폴리아미드 복합막을 상용하여 cephalosporin C를 농축하기 역삼투 농축실험을 하였다. 4-20 kg/cm2의 압력과 100-1000 mg/L의 농도, 그리고 2.8과 5.6 L/min의 유속을 갖는 실험 조건하에서 cephalosporin C 수용액의 수투과율과 용질의 배제율 및 물질전달 계수를 구하였다. Cephalosporin C를 분리하는데 있어서 압력이 증가함에 따라 투과 플럭스가 증가하는 것으로 나타났다. 이 결과는 Kedem-Katchalsky 모델에서 예측한 것과 일치하였다. 그리고 배제율은 1에 가까웠다. 또한 공급액의 농도가 증가할수록 cephalosporin C의 배제율은 낮아지는 것으로 나타났다. 배제율은 고농도보다는 저온도에서 높게 나타났으나 그 감소 정도는 작았다.
Reverse osmosis concentration for cephalosproin C was studied using a polyamide composite membrane, FT-30 in spiral wound type with high solute rejection. The experiments were carried out in the aqueous solution of cephalosporin C for water flux, solute rejection and mass transfer coefficient under applied pressure of 4-20 kg/cm2, feed concentration of 100-1000 mg/L and feed velocity of 2.8 and 5.6 L/min at room temperature. The effect of operating pressure on the separation of cephalosporin C showed that permeate flux increased with increasing operation pressure. These results are consistent with those predicted by Kedem-Katchalsky model. Solute rejection was nearly 1. The increase of feed concentration caused the reduction of cephalosporin C rejection, which was higher at low concentration than at high concentration, but degree of reduction was small.
  1. Abraham EP, Loder PB, Cephalosporins and Penicillins, Academic Press, New York (1974)
  2. Bernard A, Ferda M, biochemical Engineering and Biotechnology Handbook, 2ed. Stockton Press (1991)
  3. 신상규, 발효 및 생물분리에 의한 Cephalosporin C 생산, 박사학위논문, 성균관대학교 (1995)
  4. Amajad Z, Reverse Osmosis; Membrane Technology, Water Chemistry and Industry Application, Van Nostrand Reinhold, New York (1993)
  5. Erickson P, J. Membr. Sci., 36, 297 (1988) 
  6. Ho WSW, Sirkir KK, Membrane Handbook, Van Nostrand Reinhold, New York (1992)
  7. Sourirajan S, Ind. Eng. Chem. Fundam., 2, 1 (1963) 
  8. Reid CE, J. Appl. Polym. Sci., 1, 133 (1959) 
  9. Ronsdale HK, Merten U, Riley RL, J. Appl. Polym. Sci., 9, 1341 (1965) 
  10. Biter JGA, Transport Mechanisms in Membrane Separation Processes, Plenum Press, New York (1991)
  11. Wijmans JG, Baker RW, J. Membr. Sci., 107(1-2), 1 (1995) 
  12. Mulder M, Basic Principles of Membrane Technology, Kluwer Academic Publishers, MA (1991)
  13. 류정, 이용철, 폴리아미드 역삼투막을 이용한 m-Cresol의 제거, 성균관대학교 논문집 (과학기술편), 48, 489 (1997)
  14. Chen GH, Chai XJ, Yue PL, Mi YL, J. Membr. Sci., 127(1), 93 (1997)